Product ID:DOD-E-18210,RED DECK ENAMEL,B18210PRD
MSDS Date:08/17/1989
FSC:8010
NIIN:00-292-1812
MSDS Number: BJNLD

DAVLIN PAINT CO INC

BERKELEY, CA 94702
US

Emergency Phone: 415-889-7098

Info Phone: 415-848-2863

Preparer: PATRICIA SHAW

Cage: 3Z268

DAVLIN PAINT CO INC

2308 BERKELEY, CA 94702 US

Telephone: 510-848-2863

Cage: 3Z268

HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68 F)

CAS: 64741-41-9

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: < 5%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 4.55%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 9%

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PETROLEUM HYDROCARBONS & SYNTHETIC
LUBRICANTS POSE POTENTIAL HUMAN HEALTH RISKS. AS A PRECAUTION,
EXPOSURE TO LIQUIDS, VAPORS, MISTS OR FUMES SHOULD BE MINIMIZED.
CHRONIC EXPOSURE MAY CAUSE DAMAGE TO THE CENTRAL NERVOUS SYS,
RESPIR SYS, LUNGS, EYES SKIN, GASTROINTESTINAL TRACT, LIVER, SPLEEN
& KIDNEYS.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED AS A
CARCINOGEN.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMITITIS, NAUSEA

First Aid:INHALE: REMOVE TO FRESH AIR, ADMINISTER OXYGEN IF NEEDED.
EYE: FLUSH W/WATER FOR AT LEAST 15 MIN, OCCASIONALLY LIFTING
EYELIDS. SKIN: REMOVE CONTAMINATED ARTICLES, WASH SKIN WITH SOAP &
WATER. INGEST: GIVE WATER OR MILK, DO NOT INDUCE VOMIT UNLESS
INSTRUCTED BY PHYSICIAN. GET MEDICAL ATTENTION IMMEDIATELY FOR ANY
OF THESE CONDITIONS.

Flash Point Method:SCC
Flash Point:105 F/41 C
Lower Limits:1.O
Upper Limits:6.1
Extinguishing Media:USE WATER FOG,CARBON DIOXIDE,FOAM,DRY CHEMICAL OR
ALCOHOL FOAM
Fire Fighting Procedures:USE EXTINGUISHERS DESIGNED TO EXTINGUISH NFPA
FLAMMABLE LIQUID FIRE. USE WATER FOR A COOLANT. WEAR FULL
PROTECTIVE CLOTHING & BREATHING APP.
Unusual Fire/Explosion Hazard:VAPORS FORM EXPLOSIVE MIX W/AIR BETWEEN
LOW & HIGH EXPLOSIVE LIMITS WHICH CAN IGNITE BY MANY SOURCES.
CLOSED CONTAINERS MAY EXPLODE ISOLATE FROM IGNITE SOURCES.

Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE AREA. PROVIDE APPROPRIATE
PROTECTIVE EQUIPMENT. DIKE AROUND SPILL AREA. COVER SPILL WITH
INERT ABSORBANT AND TRANSFER USING NON-SPARKING TOOLS.

Handling and Storage Precautions:STORE BELOW 80 F IN A CLOSED
CONTAINER. STORE IN ORIGINAL CONTAINER. AVOID FLAME AND HIGH
TEMPERATURES. DO NOT STORE NEAR OXIDIZING AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL A
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASHBACK. GROUND
ALL CONNECTION, CONTAINERS, ETC WHEN POURING OR TRANSFERING TO
MINIMIZE STATIC ELECTRICIT Y. USE NON-SPARKING TOOLS.

Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT WHEN AIRBORN
EXPOSURE LIMITS ARE EXCEEDED. CONSULT RESPIRATORY MANUFACTURER FOR
APPROPRIATE EQUIPMENT. MAY REQUIRE USE OF A SUPPLIED-AIR
RESPIRATOR OR A SELF-CONTAIN ED BREATHING APPARATUS.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO CONTROL EXPOS LEV BELOW
AIRBORN EXPOS LIMITS. VENTILATION EQUIP MUST BE EXPLOS PROOF.
Protective Gloves:CONSULT SAFETY EQUIPMENT SUPPLIER.
Eye Protection:USE CHEMICAL SAFETY GLASSES OR GOGGLES
Other Protective Equipment:IMPERMEABLE APRONS & PROTECTIVE CLOTHING
WHEN POSSIBLE TO PREVENT SKIN CONTACT.USE OF HEAD CAPS IS STRONGLY
RECOMMNEDED.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AFTER USING, WASH
BEFORE EATING, TOILETING OR SMOKING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:315F,157C
Vapor Density:> THAN AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE &/OR MONOXIDE, LOW MOLEULAR WEIGHT HYDROCARBONS & ORGANIC
ACIDS.

Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.